Ferrari Mailing List: Re: 308 QV Motor Swap

[Robert W. Garven Jr. (rgarven]

redline 75.90NS

I stand by this but the oil suggested

http://ferrarichat.com/forum/technical-q-sponsored-algar-ferrari/120201-chapter-three-gearbox-oil-change-308-gt4.html

Robert W. Garven Jr.

rgarven [at] gmail.com

 "The Ferrari is a dream - people dream of owning this special vehicle and for most people it will remain a dream apart from for those lucky few." Enzo Ferrari

On Mar 15, 2015, at 3:29 PM, Matt Boyd <ferrari308driver [at] gmail.com> wrote:

Peter, your point is a very good one and it has been a while since I changed the gearbox fluid anyhow. I think that is something I should do very soon. What is everyone's favorite gearbox fluid for the 308 series cars these days? I believe last time I used some version of Swepco, but it's been a while....

-Matt

'85 euro 308

On Sat, Mar 14, 2015 at 1:06 AM, Peter Rychel <dino308gt4 [at] hotmail.com> wrote:

Sounds like a good plan.

Funny you mention 2nd AND 4th gear syncros showing signs of weakness. I've found my 2nd gear not too bad, but would have the occasional "crunch" into 4th, cold or hot. Rob Garven and I were discussing this about two years ago when I was in the midst of a service and doing the O-Ring seals on the shift-shaft on my GT4. I did some measurements and noticed that the 4th and 5th gear clusters are not touching the level of oil in the gearcase (that's based off of filling the oil until it pours out of the sight hole on the backside of the trans. case). Since then, I've OVER-filled the transmission by a half liter or so (a little more than half a quart) and 4th gear shifts much better now. Maybe because it was only getting splash lubrication before, that that just wasn't enough to allow the syncro to work properly.

I've been a member of F'Chat for 15 years, but I don't log in much as I used to.

Peter

---

Date: Fri, 13 Mar 2015 18:14:46 -0400
From: ferrari308driver [at] gmail.com
Subject: [Ferrari] 308 QV Motor Swap
CC: ferrari [at] ferrarilist.com
To: dino308gt4 [at] hotmail.com

All,

I am close to purchasing a donor motor for my 308. For the past several years I have been aware of low compression (as in about half the compression of the good side), and a leakdown reveals it needs rings. I have driven it sparingly since, and never hard (surely not at a track event). It has the original motor with well over 100k miles, and it is my goal to someday rebuild it. For the record, it is a Euro.

For the f-chatters amongst us, you may have noticed a Euro 3.0 QV motor for sale from a Mondial from a fellow who did a 3.2 transplant. Thanks to George Parker for turning me onto it since I'm not a regular f-chatter. My plan is to take my motor out and KEEP it so I have a matching numbers motor, but use this one for the time being. I hpoe to rebuild it someday. My gearbox could probably use some attention with respect to the 2nd and 4th gear syncrhos, so that will require some effort as well. I'm not sure if and what else I'll do "while I'm in there" other than really cleaning things up in the engine compartment when it is vacant. Other ideas include perhaps Rick Lindsay's 308 A/C upgrade, perhaps an aftermarket ignition, but if I'm smart I'll just put it back together and enjoy it. Oh yeah, why not put those Energy Suspension bushings in that I bought years ago, maybe rebuild the Konis, etc etc....? ;-)

I'm meeting the seller of the motor at Competizione (Richard Capoccia) on Monday for Richard to help me assess the health of the motor. Basically a leakdown test. Any comments/recommendations here would be appreciated.

For many years, my 308 was a dependable, well-maintained, sometimes daily driver. I'm not looking for a showcar or to build performance mods in, I just think a Euro 308 is about the most beautiful car out there, and I'm fortunate to have had mine for almost 20 years now, and I want to get it back to where I wouldn't hesitate to drive it across the country and back.

-Matt

'85 Euro 308

_________________________________________________________________ To unsubscribe or modify your subscription options, please visit: http://lists.ferrarilist.com/mailman/options/ferrari/dino308gt4%40hotmail.com Sponsored by BooyahMedia.com and F1 Headlines http://www.F1Headlines.com/

_________________________________________________________________
To unsubscribe or modify your subscription options, please visit:
http://lists.ferrarilist.com/mailman/options/ferrari/rgarven%40gmail.com

Sponsored by BooyahMedia.com
and F1 Headlines
http://www.F1Headlines.com/